Cloth face mask
Cloth face mask | |
---|---|
Other names | Fabric mask |
A cloth face mask is a
Cloth face masks were routinely used by healthcare workers starting from the late 19th century until the mid 20th century. In the 1960s they fell out of use in the developed world in favor of disposable surgical masks with an electret (electrically charged) filter material, but cloth masks persisted in developing countries. During the COVID-19 pandemic, their use in developed countries was revived due to shortages, as well as for environmental concerns and practicality. Launderable cloth electret filters were also being developed.[1]
Usage
Prior to the
In healthcare settings, they are used on sick patients as source control to reduce disease transmission through respiratory droplets, and by healthcare workers when surgical masks and respirators are unavailable. Cloth face masks are only recommended for use by healthcare workers as a last resort if supplies of surgical masks and respirators are exhausted.[4] They are also used by the general public in household and community settings as perceived protection against both infectious diseases and particulate air pollution and to contain the wearer's exhaled virus laden droplets.[4][5]
Several types of cloth face masks are available commercially, especially in Asia.
Recommendations
The
The
A peer-reviewed summary
Material (source) | Structure | Initial Filtration Efficiency (%) |
Initial Pressure drop (Pa) |
Filter quality factor, Q (kPa−1) |
---|---|---|---|---|
Polypropylene (interfacing material) | spunbond
|
6 | 1.6 | 16.9 |
Cotton (sweater) | knit | 26 | 17 | 7.6 |
Cotton (T-shirt) | knit | 21 | 14.5 | 7.4 |
Polyester (toddler wrap) | knit | 17 | 12.3 | 6.8 |
Cotton (T-shirt) | woven | 5 | 4.5 | 5.4 |
Cellulose (tissue paper) | bonded | 20 | 19 | 5.1 |
Cellulose (paper towel) | bonded | 10 | 11 | 4.3 |
Silk (napkin) | woven | 4 | 7.3 | 2.8 |
Cotton (handkerchief) | woven | 1.1 | 9.8 | 0.48 |
Cotton, gauze | woven | 0.7 | 6.5 | 0.47 |
Nylon (exercise pants) | woven | 23 | 244 | 0.4 |
Effectiveness
Cloth face masks can be used for source control to reduce disease transmission arising from the wearer's respiratory droplets, but are not considered personal protective equipment for the wearer[15][16][17] as they typically have very low filter efficiency.[18][19] There are no standards or regulation for self-made cloth face masks.[19]
As of 2015, there had been no randomized clinical trials or guidance on the use of reusable cloth face masks.[4][6] Most research had been performed in the early 20th century, before disposable surgical masks became prevalent. One 2010 study found that 40–90% of particles in the 20–1000 nm range penetrated a cloth mask and other fabric materials.[18] The performance of cloth face masks varies greatly with the shape, fit, and type of fabric,[5] as well as the fabric fineness and number of layers.[6] As of 2006, no cloth face masks had been cleared by the U.S. Food and Drug Administration for use as surgical masks.[3] A Vietnamese study of healthcare workers compared influenza-like illness outcome among those wearing cloth masks versus medical masks.[20] They concluded that cloth masks were ineffective at preventing transmission in high-risk clinical settings. Although discouraged in clinical settings, cloth masks may still serve a useful role in reducing disease transmission in public settings according to a systematic review.[21]
The primary role of masks worn by the general public is to "stop those who are already infected broadcasting the virus into the air around them."[22] This is of particular importance with the COVID-19 pandemic, as silent transmission seems to be a key feature of its rapid spread. For example, of the people on board the Diamond Princess cruise ship, 634 people were found to be infected—52% had no symptoms at the time of testing, including 18% who never developed symptoms.[23] It is important to note that mask wearers are more likely to engage in other hygiene measures such as hand washing and social distancing. Best practice is to implement multiple prevention techniques to reduce risk, as characterized by the Swiss cheese model.[24]
Compared with bacteria recovery from unmasked volunteers, a mask made of muslin and flannel reduced bacteria recovered on agar sedimentation plates by 99%, total airborne microorganisms by 99%, and bacteria recovered from aerosols (<4 µm) by 88% to 99%.[25] In 1975, 4 medical masks and 1 commercially produced reusable mask made of 4 layers of cotton muslin were compared. Filtration efficiency, assessed by bacterial counts, was 96% to 99% for the medical masks and 99% for the cloth mask; for aerosols (<3.3 µm), it was 72% to 89% and 89%, respectively.[26]
An experiment carried out in 2013 by Public Health England, that country's health-protection agency, found that a commercially made surgical mask filtered 90% of virus particles from the air coughed out by participants, a vacuum cleaner bag filtered out 86%, a tea towel blocked 72% and a cotton t-shirt 51%—though fitting any DIY mask properly and ensuring a good seal around the mouth and nose is crucial.[27][22] The use of common fabrics in making face masks has been tested.[28][29][30][31] Filter efficiency can be improved with multiple layers, high weave density, and a mix of different types of fabrics. Cotton is the most commonly used material, and filter efficiencies can reach >80% for particles <300 nm with fabric combinations such as cotton-silk, cotton-chiffon, or cotton-flannel.[31] The most protective cloth masks need at least three layers with a hydrophilic inner layer (e.g. cotton) to absorb moisture from the wearer's breathing and hydrophobic outer layers (e.g. polyester).[13] Masks should be cleaned after each use. They can either be laundered or hand-washed in soapy hot water and dried with high heat.[32]
History
In Roman times,
Conventional
In 1890 William Stewart Halsted pioneered the use of rubber gloves and surgical face masks, although some European surgeons such as Paul Berger and Jan Mikulicz-Radecki had worn cotton gloves and masks earlier. These masks became commonplace after World War I and the Spanish flu epidemic of 1918.[39][40] Cloth face masks were promoted by Wu Lien-teh in the 1910–11 Manchurian pneumonic plague outbreak, although Western medics doubted their efficacy in preventing the spread of disease.[41]
Cloth masks were largely supplanted by modern surgical masks made of nonwoven fabric in the 1960s,[3][6] although their use continued in developing countries.[4] They were used in Asia during the 2002–2004 SARS outbreak, and in West Africa during the 2013–2016 Ebola epidemic.[4] Compared with bacteria recovery from unmasked volunteers, a mask made of muslin and flannel reduced bacteria recovered on agar sedimentation plates by 99%, total airborne microorganisms by 99%, and bacteria recovered from aerosols (<4 µm) by 88% to 99%.[25] In 1975, 4 medical masks and 1 commercially produced reusable mask made of 4 layers of cotton muslin were compared. Filtration efficiency, assessed by bacterial counts, was 96% to 99% for the medical masks and 99% for the cloth mask; for aerosols (<3.3 µm), it was 72% to 89% and 89%, respectively.[26]
COVID-19 pandemic
During the COVID-19 pandemic, most countries recommended the use of cloth masks to reduce the spread of the virus.[42]
On June 5, 2020, WHO changed its advice on face masks, recommending that the general public should wear fabric masks where widespread COVID-19 transmission exists and physical distancing is not possible (for example, "on public transport, in shops or in other confined or crowded environments").[43][44]
See also
References
- PMID 32371574.
- ^ a b c "Use of Cloth Face Coverings to Help Slow the Spread of COVID-19". U.S. Centers for Disease Control and Prevention. April 4, 2020. Retrieved April 5, 2020. This article incorporates text from this source, which is in the public domain.
- ^ ISBN 978-0-309-10182-0.
- ^ S2CID 46366687.
- ^ S2CID 8794360.
- ^ ISSN 1996-9783.
- ISSN 0362-4331. Retrieved March 28, 2022.
- ^ a b "Coronavirus: WHO advises to wear masks in public areas". BBC. June 6, 2020.
- ^ "Recommendation Regarding the Use of Cloth Face Coverings, Especially in Areas of Significant Community-Based Transmission". CDC. April 3, 2020.
- ^ "5 Myths About Coronavirus and Face Masks, Debunked. Are you wearing yours the right way?". Cleveland Clinic. June 4, 2020.
- ^ "COVID-19: How much protection do face masks offer?". Mayo Clinic. May 28, 2020.
- ^ "Coronavirus Face Masks & Protection FAQs". Johns Hopkins School of Medicine. June 25, 2020.
- ^ a b c d "Advice on the use of masks in the context of COVID-19". WHO. June 5, 2020.
- ^ Clase, C.M., Fu, E.L.F., Ashur, A., Beale, R.C.L., Clase, I.A., Dolovich, M.B., Jardine, M.J., Joseph, M., Kansiime, G., Mann, J.F.E., Pecoirs-Filho, R., Winkelmayer, W. C. and Carrero, J. J. Forgotten technology in the COVID-19 pandemic. Filtration properties of cloth and cloth masks: a narrative review. Mayo Clinic Proceedings 2020; https://www.mayoclinicproceedings.org/article/S0025-6196(20)30826-0/fulltext
- PMID 32787926.
- ^ "FAQs on the Emergency Use Authorization for Face Masks (Non-Surgical)". U.S. Food and Drug Administration. April 26, 2020. Retrieved May 21, 2020.
- ^ "Meat and Poultry Processing Workers and Employers". U.S. Centers for Disease Control and Prevention. April 26, 2020. Retrieved May 8, 2020.
- ^ PMID 20584862.
- ^ a b "Using face masks in the community - Reducing COVID-19 transmission from potentially asymptomatic or pre-symptomatic people through the use of face masks". European Centre for Disease Prevention and Control. April 8, 2020. Retrieved May 21, 2020.
- PMID 25903751.
- medRxiv 10.1101/2020.05.07.20093864.
- ^ ISSN 0013-0613. Retrieved April 20, 2020.
- ISSN 0013-0613. Retrieved April 20, 2020.
- ^ https://my.clevelandclinic.org/-/scassets/files/org/employer-solutions/covid-19-workplace-safety-faqs.ashx [bare URL PDF]
- ^ PMID 13901536]
- ^ PMID 1203649]
- PMID 24229526.
- PMID 18612429.
- PMID 24229526.
- PMID 20584862.
- ^ PMID 32329337.
- ^ "Coronavirus: How to Care for Your Face Mask". www.hopkinsmedicine.org. Retrieved August 4, 2020.
- ^ "Gauze Mask to Halt Spread of Plague". The Washington Times. September 27, 1918. p. 3.
- ^ George, Nirmala (September 11, 2005). "Jain Ascetics Give It All Up for Their Faith". Los Angeles Times. Retrieved October 31, 2020.
- New York Times. Retrieved October 31, 2020.
- ^ "Jainism in India". people.uwec.edu. Archived from the original on November 1, 2020. Retrieved October 31, 2020.
- ^ "The History of Respirator". Cambridge Mask Co. March 28, 2016.
The idea of using respirators was pioneered by Pliny the Elder in the first century A.D. when he recommended the use of animal bladder to protect Roman miners from inhaling lead oxide dust. Early inventions did not stop with Pliny as in the 16th century, Leonardo da Vinci, advised the use of a wet woven cloth to protect against toxic agents of chemical warfare.
- ^
Guttmacher, Peter (1995). Legendary Westerns. MetroBooks. p. 17. ISBN 9781567991727. Retrieved August 21, 2020.
Before Sam Peckinpah ever wore a bandana , before Paul Newman and Robert Redford ever got into western gear, these gentlemen train robbers [...]
- Fielding H. Garrison (1921). History of Medicine(3rd ed.). Philadelphia W.B. Saunders. p. 761.
- S2CID 219563013.
- PMID 30427733.
- ^ "Which Countries Are Requiring Face Masks?". Council on Foreign Relations. Retrieved January 5, 2021.
- ^ "Advice on the use of masks in the context of COVID-19: Interim guidance". World health Organization. June 5, 2020. p. 7. Retrieved August 21, 2020.
Table 2: Examples of where the general public should be encouraged to use medical and non-medical masks in areas with known or suspected community transmission
- ^ "Coronavirus: WHO advises to wear masks in public areas". BBC News. June 6, 2020.
[...] WHO director-general Dr Tedros Adhanom Ghebreyesus said on Friday that 'in light of evolving evidence, the WHO advises that governments should encourage the general public to wear masks where there is widespread transmission and physical distancing is difficult, such as on public transport, in shops or in other confined or crowded environments'.