Puna Geothermal Venture

Coordinates: 19°28′43″N 154°53′20″W / 19.4785°N 154.8888°W / 19.4785; -154.8888
Source: Wikipedia, the free encyclopedia.

Puna Geothermal Venture
MW
External links
Websitehawaiianelectric.com/clean-energy-hawaii/clean-energy-facts/renewable-energy-sources/geothermal/puna-geothermal-venture-(pgv)
CommonsRelated media on Commons
[edit on Wikidata
]

The Puna Geothermal Venture (PGV) is a

lava fountains erupted nearby, eventually also cutting off road access.[2][3]

PGV is the first and only commercial geothermal power plant in Hawaii. Constructed on a site adjacent to failed experimental wells drilled and operated by the Hawaii Geothermal Project in the 1970s and 80s, construction on the generating facility began in 1989 and was completed in 1993.

Prior to the lava damage, the plant had an installed generating capacity of 38 MW

Hawaiian Electric Industries (also known as HELCO).[5] The plant generated up to 10% of the island’s electrical energy as of 2018.[6]

History

Early exploration and development

The first exploratory geothermal wells in

Honolulu Advertiser that the company "had mechanical difficulties and gave up."[8]
: 12–13 

Hawaii Geothermal Project

In the 1970s, the Hawaii Geothermal Project was formed to conduct federal and state-funded research.

environmental impact studies or a period for public input. At the time, the area around the drill site was rural and undisturbed, but subdivisions were planned nearby.[8]: 14–15  The well was occasionally allowed to discharge gas and fluid from the borehole, which created a loud noise and release pollutants into the air. By 1976, three subdivisions nearby had been established and were beginning to house residents, including twelve families who lived within one mile of the well. The continued noise pollution and toxic gas discharges began to cause concern and opposition from the residents. Funds were secured from the federal and state governments to turn the well's geothermal energy into electricity.[8]: 15–19  Although HELCO was among the project stakeholders, they assured stockholders that they would not invest the company's capital in the project due to the volcanic and seismic risk at the site.[8]
: 19 

An experimental 3 MW generator was completed in 1981 and remained operational throughout the 1980s. However, families continued to build and move into the nearby subdivisions, resulting in several attempts and a failed lawsuit to stop the noise and pollution.

kilowatt hours of electricity annually.[9]
: 13 

Puna Geothermal Venture

Map
About OpenStreetMaps
Maps: terms of use
4km
2.5miles
Leilani Estates
Leilani Estates
Puna Geothermal Venture
Puna Geothermal Venture
.

In 1980, HELCO requested a proposal for 25 MW of geothermal electricity generation. A joint venture was formed that year between two of Lyman's companies and two other companies to produce geothermal energy on a 500-acre (200 ha) parcel leased from the Lyman family. The joint venture was renamed Puna Geothermal Venture in 1981. Over the following years, PGV drilled three wells, but all suffered from well casing mechanical failures and were unusable.[8]: 39–41 

In 1986, PGV secured a contract with HELCO to supply 25 MW of electricity by 1993. PGV promised that they would adopt technology that would result in zero emissions and operate at a drastically lower noise level. In 1989, when the HGP facility was facing growing problems, the PGV proposed facility managed to overcome enough local opposition to be granted a permit from the local

planning commission.[8]
: 41–45 

The plant raised local concerns as a result of occasional toxic emissions.

Environmental Protection Agency standards regarding hydrogen sulfide releases and was fined $76,500 for two incidents in 2013.[13][14] Additional concerns and opposition to the plant were raised by Native Hawaiians, who viewed all forms of volcanic activity as demigod Pele manifestations. They declared geothermal wells and energy production to be a desecration.[7]
: 7 

In 2005 during the drilling of the KS-13 well, magma was encountered at a depth of 8,163 ft (2,488 m). The borehole had to be redrilled several times as the magma flowed up the borehole, cooling into clear, colorless glass. The magma, at a temperature of approximately 1922 °F (1050 °C), was

silica, which contrasts with the dark, iron-rich basaltic rock that forms most of the Hawaiian Islands. It was encountered after drilling through a 240 ft (73 m) layer of diorite igneous rock, which suggested to researchers that the magma had chemically separated as it dwelled for a long period.[15][16][17][18] As quoted in Nature, the team said it was possibly the first time that "the actual process of differentiation of continental-type rock from primitive ocean basalt has been observed in situ".[15] Magma specialist Bruce Marsh of Johns Hopkins University described the uniqueness of the encounter: "Before, all we had to deal with were lava flows; but they are the end of a magma's life. They're lying there on the surface, they've de-gassed. It's not the natural habitat. It's the difference between looking at dinosaur bones in a museum and seeing a real, living dinosaur roaming out in the field."[18]

PGV had a generating capacity of 25 MW when it opened in 1993, growing to 30 MW in 1995 and 38 MW in 2012.[7]: 9  In 2015, HELCO announced that Ormat was the winner of a bid to add 25 MW of geothermal generating capacity in the Puna district.[19][10][7]: 25  In March 2018, Ormat announced their plan to increase production at the plant by 8 MW—from 38 MW to 46 MW—by 2020.[20]

Lava damage and closure in 2018

Further information: 2018 lower Puna eruption
Puna Geothermal Venture
Click here to expand this image
Southern part of the Puna Geothermal Venture (red circle) is seen nearby the lava fountains of Kīlauea volcano

On May 3, 2018 earth fissures opened inside and around the

Leilani Estates subdivision near the PGV plant, following hundreds of earthquakes over the first two days of May. Concerns of possible toxic hydrogen sulfide gas releases and explosions at the geothermal power facility led to preemptive equipment shutdowns and inventorying its stockpile of highly-flammable pentane. Earthquake frequency began increasing and the first cracks appeared in Leilani Estates on May 1–2; the plant was taken off-line approximately three hours after it received the first report that lava had begun to flow on May 3.[21] All pentane stored at PGV, approximately 60,000 US gallons (230,000 L; 50,000 imp gal), was removed by the morning of May 10.[22]

Over the following weeks, the wells were stabilized with cold water—the weight of the water was sufficient to prevent steam from rising—and allow them to be plugged. One well, KS-14, possibly super-heated from close proximity to magma, could not be quenched and was filled with drilling mud in an attempt to stabilize it. The wells were then sealed with metallic plugs, which arrived at the site on May 22, that PGV officials claimed could withstand 2000 °F (1100 °C) lava.[23][24][25][26][27][28] Tom Travis of the Hawaii Emergency Management Agency, claimed that he researched and was unable to find any precedent for lava overrunning a geothermal well that had been shut down like the wells at PGV. The PGV team had spoken with scientists in Iceland who have operated wells within lava fields and provided insights into how lava might affect the wellhead.[28]: 8:03–9:26 

Lava approached several of the capped wells on May 27.[2] Capped KS-5 and KS-6 wells were inundated by the lava from fissures 7 and 21 on May 27 and 28.[29][30] The event was the first time lava had covered a geothermal well.[31][32] On May 30 a substation and a warehouse containing a drilling rig were overrun and destroyed by molten rock, cutting the main access road to the facility.[33] A third well was inundated thereafter.[3]

Despite the shutdown, Hawaii Electric Light did not expect blackouts on the Big Island to be caused by insufficient power generation as older, diesel-fueled generators were brought on-line.[34][35][25]

2020 restart and 2022 proposed expansion

Work began on drilling in late 2019.[36] The plant resumed reduced operations in November 2020.[1]

As of early 2022, the Puna Geothermal Venture power plant was reported to be producing approximately 25.7 MW of electric power for the Big Island.

In July 2022 it was announced that an expansion of PGV's power output was proposed.[37] The plan, called the Repower Project, has a goal of 46 MW in Phase 1 and then to 60 MW in Phase 2, and would implement the increase in power generation by replacing 12 operating power-generating units with as many as four upgraded power-generating units, operating on the existing grounds of the current facility.

PGV published an

Environmental Impact Statement Preparation Notice on the July 23, 2022 edition of “The Environmental Notice,” stating there will be a 30-day public review period. Comments submitted by the public were required to be received by August 22, 2022, with a Public Scoping Meeting to be held August 17 at the Pahoa Community Center.[38]

Kapoho Geothermal Reservoir

PGV is located in the East Rift Zone of the

Hawaii Island. The geothermal energy reservoir there is known as the Kapoho Geothermal Reservoir.[9]: 11  The geothermal energy potential of the East Rift Zone is estimated to exceed 200 MW.[39] The geothermal reservoir is contained within basaltic rock and relies on the permeability of two major fracture systems. Both fracture systems have large openings, recorded by the drop of 8.5 in (220 mm) drillbits for up to 30 ft (9.1 m).[40]

Facilities

Map
About OpenStreetMaps
Maps: terms of use
200m
220yds
Pad A
Pad A
Pad B
Pad B
Binary cycle plant
Binary cycle plant
Combined cycle plant
Combined cycle plant
Pad F
Pad F
Pad E
Pad E
Pad D
Pad D
Location of plants and well pads[7][41]

The plant is owned by Ormat Technologies which purchased it in 2004.[42]

Power plants

Two power plants operate in the Puna Complex. The first plant consists of ten

Combined cycle Ormat Energy Converters (OEC) made up of ten steam turbines and ten binary turbines and opened in 1993.[43] The second plant consists of two Binary cycle
OECs that entered service in 2011 and commenced commercial operation in 2012.

Wells

As of December 2017, six production wells and five injection wells made up the Puna Complex.[43]

List of wells as of September 2014[44]
Well Wellfield Type Depth Status after 2018 eruption
Kapoho State 1A (KS-1A) Pad A Injection
Kapoho State 3 (KS-3) Pad E Injection
Kapoho State 5 (KS-5) Pad E Production Covered by lava
Kapoho State 6 (KS-6) Pad E Production 6,532 feet (1,991 m) Covered by lava
Kapoho State 9 (KS-9) Pad A Production
Kapoho State 10 (KS-10) Pad A Production 5,210 feet (1,590 m)
Kapoho State 11 (KS-11) Pad A Injection 6,500 feet (2,000 m)
Kapoho State 13 (KS-13) Pad A Injection 8,297 feet (2,529 m)
Kapoho State 14 (KS-14) Pad E Production In proximity to magma
Kapoho State 15 (KS-15) Pad B Injection
Kapoho State 16 (KS-16) Pad A Production
Kapoho State 17 (KS-17) Pad E Production

As of 2008, the five active production wells had a surface elevation of 620 ft (190 m) above sea level and produce a mixture of steam and brine. The five wells produced an average of 600,000 lb/hour (270,000 kg/hour) of steam and 1,200,000 lb/hour (545,000 kg/hour) of brine. The temperature of fluids emerging from the production wells is approximately 640 °F (338 °C), which is returned to the injection wells at approximately 300–400 °F (150–200 °C).[40][45]

Alternative uses of geothermally-heated fluids

In addition to electricity generation, additional uses of the facility have been suggested. Andrea Gill of the Hawaii Department of Business, Economic Development, and Tourism—on behalf of a working group established to consider direct uses of the geothermal energy at PGV and its vicinity—outlined potential direct uses of the fluids as well as shallow groundwater wells in its vicinity, including fruit and

geothermal heat pumps.[45] At PGV, hot brine after being utilized to generate electricity is approximately 300–400 °F (150–200 °C) when it is reinjected; the brine could be tapped for its thermal energy before reinjection. Water wells under 750 ft (230 m) in the vicinity of PGV have recorded temperatures up to 193 °F (89 °C).[45]

In 2005, after a drill hit an uncommonly-observed type of magma, researchers and PGV expressed a desire to turn the borehole into an observatory for scientific studies.[15]

References

  1. ^ a b "Puna Geothermal Venture Goes Back Online". Big Island Video News. November 12, 2020.
  2. ^
    Star Advertiser
    . May 27, 2018.
  3. ^
    Star Advertiser
    . July 8, 2018.
  4. ^ "Renewable Energy & Storage Projects". www.hawaiianelectric.com.
  5. ^ "Puna Geothermal Venture (PGV)". www.hawaiianelectric.com.
  6. ^ "Hawaii Electricity Profile Analysis". U.S. EIA. Retrieved February 3, 2021.
  7. ^ a b c d e Schroeder, Martin (May 27, 2016). "A Renewable Energy Solution on Hawaii Island – The Puna Geothermal Plant" (PDF). Ormat Technologies. Retrieved May 30, 2018.
  8. ^ a b c d e f g h i Szvetecz, Annie (August 2001). Geothermal energy in Hawai'i: an analysis of promotion and regulation (PDF) (MSc thesis). ProQuest LLC. Retrieved May 30, 2018.
  9. ^ a b c Boyd, Tonya L.; Thomas, D.; Gill, A. T. (September 2002). "Hawaii and Geothermal-What Has Been Happening" (PDF). Geo-Heat Center Quarterly Bulletin. 23 (3): 11–21. Retrieved June 14, 2018.
  10. ^ a b Hunt, Tam (March 20, 2015). "Is Going Bigger on Geothermal a Good Move for the Big Island?". Greentech Media. Retrieved May 30, 2018.
  11. ^ "At Puna Geothermal Venture, Success Is Always Just Around the Corner". www.environment-hawaii.org.
  12. ^ Essoyan, Susan (June 15, 1991). "Blowout Shuts Geothermal Unit in Hawaii". Los Angeles Times. Retrieved June 9, 2018.
  13. KHON2. Nexstar Media Group
    . January 12, 2016.
  14. ^ Higuchi, Dean (January 12, 2016). "EPA finds Puna Geothermal Venture violated chemical safety rules" (Press release). Honolulu: EPA. Retrieved May 30, 2018.
  15. ^
    doi:10.1038/news.2008.1317
    . Retrieved June 2, 2018.
  16. ^ "Abstract: Dacite Melt at the Puna Geothermal Venture Wellfield, Big Island of Hawaii". American Geophysical Union. Retrieved June 2, 2018.
  17. ^ "Abstract:Dacite Melt at the Puna Geothermal Venture Wellfield, Big Island of Hawaii". ResearchGate. Retrieved June 2, 2018.
  18. ^ a b Amos, Jonathan (December 17, 2008). "Drillers break into magma chamber". BBC News. Retrieved June 2, 2018.
  19. ^ Cocke, Sophie (February 24, 2015). "Ormat Awarded Big Island Geothermal Contract". Honolulu City Beat. Retrieved May 30, 2018.
  20. ^ Kim, Alice (March 17, 2018). "Puna Geothermal Venture Increasing Production". Hawai'i Groundwater & Geothermal Resources Center. Retrieved May 30, 2018.
  21. ^ "VIDEO: Puna Geothermal Concerns At Eruption Meeting". Big Island Video News. May 5, 2018. Retrieved May 30, 2018.
  22. ^ "Crews remove pentane gas from Puna geothermal plant amid safety concerns". Hawaii News Now. May 8, 2018. Retrieved May 30, 2018.
  23. ^ "Wells are hurriedly plugged at Hawaii power plant under threat of lava flow". Los Angeles Times. AP. May 23, 2018. Retrieved May 30, 2018.
  24. ^ Burnett, John (May 21, 2018). "Official: As lava approaches, workers close to capping geothermal wells". Hawaii Tribune Herald. Retrieved May 30, 2018.
  25. ^ a b "Puna Geothermal Venture deemed stable after lava covers two wells". KHON. May 28, 2018. Retrieved May 30, 2018.
  26. ^ "State says well field at Puna Geothermal 'essentially safe'". Hawaii News Now. May 21, 2018. Retrieved May 30, 2018.
  27. ^ "VIDEO: As Lava Nears, Officials Working To Kill Geothermal Wells". Big Island Video News. May 21, 2018. Retrieved May 30, 2018.
  28. ^ a b Tom Travis (May 21, 2018). As Lava Nears, Officials Working To Kill Geothermal Wells (May 21, 2018) (Press conference recording). Big Island Video News. Retrieved May 21, 2018.
  29. ^ Lincoln, Mileka. "Lava covers at least 1 well at Puna geothermal plant; governor says risk is 'mitigated'". Hawaii News Now.
  30. ^ "Some Leilani Estates residents ordered to evacuate immediately". Hawaii Tribune-Herald.
  31. ^ Rosa, Jolyn. "Lava covers potentially explosive well at Hawaii geothermal plant". Reuters. Retrieved May 28, 2018.
  32. ^ Burnett, John (May 28, 2018). "Lava takes 10 homes, covers another geothermal well". Hawaii Tribune-Herald. Retrieved May 29, 2018.
  33. ^ "Lava burns 2 buildings at Puna Geothermal plant". Honolulu Star-Advertiser. The Associated Press. June 2, 2018.
  34. ^ Proctor, Darrell (May 23, 2018). "Officials Say No Risk of Blackout From Lava Breach at Hawaii Geothermal Plant". Power Magazine.
  35. ^ "Hawaii Electric Light expects sufficient power even with geothermal plant shut do" (Press release). Hawaii Electric Light. May 3, 2018. Retrieved May 30, 2018.
  36. ^ Daysog, Rick (October 10, 2019). "Puna Geothermal Venture to drill new well as it prepares to resume operations". Hawaii News Now.
  37. ^ "5 years after lava nearly destroyed it, Puna Geothermal announces expansion plans". Hawaii News Now. May 9, 2023. Retrieved May 9, 2023.
  38. ^ "Puna geothermal site in Hawaii to expand capacity with Repower project". thinkgeoenergy.com.
  39. ^ "Geothermal Technologies Program: Tapping the Earth's energy to meet our heat and power needs" (PDF). U.S. Department of Energy, Office of Energy Efficiency and Renewable Energy. April 2004. Retrieved June 2, 2018.
  40. ^ a b Fitch, David; Matlick, Skip (2008). "Gold, silver and Other Metals in scale— Puna Geothermal Venture, Hawaii" (PDF). GRC Transactions. 32: 385–388. Retrieved June 2, 2018.
  41. ^ "Puna Geothermal Venture". Hamilton Library, University of Hawai'i at Manoa.
  42. ^ "Puna Geothermal Venture - Hawai'i Groundwater & Geothermal Resources Center". www.higp.hawaii.edu.
  43. ^ a b "2017 Annual report" (PDF). Ormat Technologies.
  44. ^ "Noncovered Source Permit Review Summary (Renewal)" (PDF). health.hawaii.gov.
  45. ^ a b c Gill, Andrea T. (2004). "Prospective Direct Use Enterprises in Kapoho, Hawaii" (PDF). Hawaii Dept. of Business, Economic Development and Tourism, Strategic Industries Division. Retrieved June 2, 2018.

External links

Wikimedia Commons has media related to Kilauea 2018 eruptions.
Retrieved from "https://en.wikipedia.org/w/index.php?title=Puna_Geothermal_Venture&oldid=1209775651"